2006 FORD E-350 PROBLEMS


Issues by Year
Click on the chart bars to get detailed information about years to avoid
Malfunction Modules
Complaints and Common Faults
-
1. EGR valve problems
- EGR valve problems, check engine light illuminated.
- EGR valve problems, check engine light illuminated.
-
2. Rust damage
- 2006 Ford E-350 cutaway with thomas bus body has severe rust damage to structural floor support beam immediately in front of rear wheels.
- 2006 Ford E-350 cutaway with thomas bus body has severe rust damage to structural floor support beam immediately in front of rear wheels.
-
3. Clutch fan, wiring defect, and check light
- 2006 Ford E-350's check light illuminated, the clutch fan had problems and there was a wiring defect.
- 2006 Ford E-350's check light illuminated, the clutch fan had problems and there was a wiring defect.
-
4. Fuel tank delamination
- Aluminum coating delaminating from fuel tank in 2006 Ford E-350 diesel van. This problem causes vehicle to stall, frequent filter changes, fuel pump failure.
- Fuel tank in my diesel Ford van (2006) is delaminating. I had 2 injectors replaced along with the fuel regulator as a result of this defective fuel tank.
- Aluminum coating delaminating from fuel tank in 2006 Ford E-350 diesel van. This problem causes vehicle to stall, frequent filter changes, fuel pump failure.
-
5. Transmission shifting issues
- 2006 Ford Econoline E350, transmission started shifting erratically causing him to lose control.
- 2006 Ford Econoline E350, transmission started shifting erratically causing him to lose control.
-
6. Brake pedal and accelerator pedal issue
- Brake pedal and accelerator pedal too close together and same height leading too two occurrences of catching accelerator during braking, one causing several hundred dollars damage.
- Brake pedal and accelerator pedal too close together and same height leading too two occurrences of catching accelerator during braking, one causing several hundred dollars damage.
-
7. Loss of power steering and brakes
- Failure of injectors and internal oil cooler led to immediate engine shut down causing immediate loss of power steering, power brakes, etc.
- Failure of injectors and internal oil cooler led to immediate engine shut down causing immediate loss of power steering, power brakes, etc.
-
8. Tire issues
- Failure to replace recalled tires
- Tire blow out on a 2006 Ford E350 5.4 liter engine.
- Failure to replace recalled tires
-
9. Steering issues
- Steering is very slow to center after making a turn; at highway speeds will not center.
- The steering on our 2006 pleasure-way rv van conversion model excel ts on a Ford E-350 chassis completely gave out while the vehicle was being driven.
- Steering is very slow to center after making a turn; at highway speeds will not center.
-
10. Electrical system problems
- Sudden fuel leak from the fuel filter mounting housing.
- While turning the vehicle at various speeds, the contact heard a clicking sound near the steering column.
- Sudden fuel leak from the fuel filter mounting housing.
-
11. Rollover risk
- Apparently the advanced track system (stabilizes the van to prevent rollover) automatically performs tests. The problem is that it does it randomly and while I'm driving.
- Apparently the advanced track system (stabilizes the van to prevent rollover) automatically performs tests. The problem is that it does it randomly and while I'm driving.
-
12. Safety belt issues
- The contact stated the buckle part of the seat belts fell into the seat and was hard to reach.
- During safety checks on a 2006 Ford E-350 15 passenger (church) van it was observed that approximately 9 of the 13 rear passenger seat belts were unavailable because the belts or buckles had slipped down through the seat cushions.
- The contact stated the buckle part of the seat belts fell into the seat and was hard to reach.
-
13. Fire hazard
- The vehicle was parked at the contact's job for two hours when he was notified that the hood was on fire.
- The vehicle was parked at the contact's job for two hours when he was notified that the hood was on fire.
-
14. Acceleration issues
- While driving 60 mph the contact depressed the brake pedal and the engine completely shut off.
- While driving 60 mph the contact depressed the brake pedal and the engine completely shut off.
-
15. Power brake failure
- While driving 10 mph the contact applied the brakes and the engine would not move.
- While driving 10 mph the contact applied the brakes and the engine would not move.
-
16. Vibration and steering issues
- While driving 60 mph the steering began vibrating and shaking. The road conditions were clear.
- While driving 60 mph the steering began vibrating and shaking. The road conditions were clear.
-
17. Air conditioning problems
- While driving approximately 35 mph, the rear air conditioning unit failed to blow out cool air.
- While driving approximately 35 mph, the rear air conditioning unit failed to blow out cool air.
Other Models
- Aerostar Number of complaints: 3018
- Aspire Number of complaints: 278
- Bronco Number of complaints: 1374
- Bronco II Number of complaints: 257
- Bronco Sport Number of complaints: 534
- C-Max Number of complaints: 363
- C-Max Energi Number of complaints: 127
- C-Max Hybrid Number of complaints: 172
- Contour Number of complaints: 4342
- Crown Victoria Number of complaints: 3490
- E-150 Number of complaints: 1375
- E-250 Number of complaints: 427
- E-350 Number of complaints: 1416
- E-450 Number of complaints: 483
- E-550 Number of complaints: 91
- EcoSport Number of complaints: 1081
- Edge Number of complaints: 13049
- Escape Number of complaints: 27892
- Escape Hybrid Number of complaints: 1666
- Escort Number of complaints: 4937
- Escort ZX2 Number of complaints: 91
- Excursion Number of complaints: 1344
- Expedition Number of complaints: 9654
- Explorer Number of complaints: 34754
- Explorer Sport Number of complaints: 895
- Explorer Sport Trac Number of complaints: 881
- F-150 Number of complaints: 38224
- F-250 Number of complaints: 10492
- F-250 Super Duty Number of complaints: 3446
- F-350 Number of complaints: 5984
- F-350 Super Duty Number of complaints: 2099
- F-450 Number of complaints: 127
- F-450 Super Duty Number of complaints: 555
- F-550 Number of complaints: 74
- F-550 Super Duty Number of complaints: 550
- F-650 Number of complaints: 54
- F-650 Super Duty Number of complaints: 43
- F-750 Number of complaints: 11
- F-750 Super Duty Number of complaints: 9
- Festiva Number of complaints: 170
- Fiesta Number of complaints: 3686
- Five Hundred Number of complaints: 1466
- Flex Number of complaints: 1775
- Focus Number of complaints: 26424
- Focus Electric Number of complaints: 285
- Focus RS Number of complaints: 5
- Freestar Number of complaints: 3143
- Freestyle Number of complaints: 4914
- Fusion Number of complaints: 25001
- Fusion Energi Number of complaints: 199
- Fusion Hybrid Number of complaints: 1202
- LTD Number of complaints: 55
- Maverick Number of complaints: 757
- Mustang Number of complaints: 10395
- Mustang GT Number of complaints: 811
- Mustang Mach-E Number of complaints: 561
- Probe Number of complaints: 1452
- Ranger Number of complaints: 9595
- Ranger EV Number of complaints: 30
- Taurus Number of complaints: 22987
- Taurus SHO Number of complaints: 183
- Taurus X Number of complaints: 213
- Tempo Number of complaints: 1602
- Thunderbird Number of complaints: 3011
- Topaz Number of complaints: 19
- Transit Number of complaints: 608
- Transit Connect Number of complaints: 533
- Windstar Number of complaints: 18774